fullfatrr.com - View topic - FUEL FILTER ON TDV8 4.4

Advertise on fullfatrr.com »

Forum · Gallery · Wiki · Shop · Sponsors

Home · FAQ · New Posts · My Posts · PMs · Search · Members · Map · Calendar · Profile · Donate · Register · Log In

Home > Maintenance & Mods (L322) > FUEL FILTER ON TDV8 4.4

Page 1 of 2

Print this entire topic ·

EmiratesA380

Member Since: 14 Jan 2015
Location: england
Posts: 361

2019 Range Rover SVAutobiography 5.0 SC V8 Aintree Green

FUEL FILTER ON TDV8 4.4

I hope this will be helpful to someone on here: ( KNOWLEDGE IS KING as is this Forum )

HOW TO CHANGE FUEL FILTER ON TDV8 4.4

I tend to do our RR's every 10,000 miles - time takes me 6 Minutes !

1. Ensure you have Genuine LR Fuel Filter: Part Number: LR072610

2. See location of Fuel Filter picture below:
NOTE: You will see part number stamped on BH42-9C296-AB - this has been superseded by BH42-9C296-AC

Click image to enlarge

3. Gentle PULL OFF the lower water sensor plug which is located at the bottom of OLD Fuel Filter. ( Tight fit with your hand - PULL OFF )

4. Ensure you move this plug out of harms way - this will be needed again once the NEW fuel filter is back in place.

Click image to enlarge

5. UNSCREW the locking cap Anti-Clockwise by hand ( you may need a large pair of grippers ) will be tight to loosen.

6. Unscrew and gentle lift out OLD Fuel filter out.

7. The NEW Fuel filter will have supplied a NEW Rubber caskit attached - KEEP SAFE.( see pic )

8. Gentle UNSCREW again Anti Clockwise the Aluminium water drain basin - THIS WILL BE NEEDED ON THE NEW Fuel Filter
You will want to clean this piece as I have done ( Keep things new )

9. Attach the existing LR Water sensor housing with the NEW Rubber washer supplied - Ensure nice tight fit

10. SLIDE THE LARGE BLACK PLASTIC Thread Locking Nut into/through the New Fuel Filter and Position back into Fuel Filter housing

11. ENSURE you get the Pressed insert collar (see the side of the new fuel filter) into the slide position on the Female top ( It is not screwed in just pushed up into position ) - The Large Black Plastic Thread Locking Nut will screw on - Push Fuel canister UP by hand and Screw Locking Collar on and into position.

12. This large Black Plastic Tread Lock - Needs to be securely Tight - do not use plastic gloves - better with your hand ( CLOCKWISE THREAD - Enure it is a Flush Tight Fit - check by eye.

13. When all the above is back in position - CLIP on the LR Water Sensor at the base of the Fuel Filter - It is pushed on only. PUSH HOME to Ensure.

14. To Prime the system all you need to do is:

Turn Ignition on WAIT 30 Seconds - DO NOT START CAR
Switch OFF Ignition and repeat
Turn Ignition on WAIT 30 Seconds - DO NOT START CAR
Switch OFF Ignition and repeat
Turn Ignition on WAIT 30 Seconds - DO NOT START CAR
Switch OFF Ignition and repeat
Turn Ignition on WAIT 30 Seconds - DO NOT START CAR

The System will self bleed any air back to the fuel tank

15. Start the RR and check for any leaks - to which there should be none ( Double Check with Engine running )

I would recommend the Fuel Filter is changed every 20,000 miles - ITS THAT EASY - 6 minutes when you know

Again hope this is helpful to you -

Happy Flying

JOB DONE

Click image to enlarge

18th Dec 2015 5:46pm

stan
Site Moderator

Member Since: 13 Jul 2010
Location: a moderate moderated moderator moderating moderately in moderation
Posts: 35878

nice write up, entered into the wiki.. ... - .- -.

Y. O. L. O.
.

18th Dec 2015 6:14pm

EmiratesA380

Member Since: 14 Jan 2015
Location: england
Posts: 361

Hi Stan

We all try our best -

I've said it before - What a Great FORUM !

Thanks for hosting the site and your time you put into it

Best wishes

E7777

18th Dec 2015 6:37pm

stan
Site Moderator

Member Since: 13 Jul 2010
Location: a moderate moderated moderator moderating moderately in moderation
Posts: 35878

you're welcome but its martin thats the owner so all kudos to him , i just moderate ... - .- -.

Y. O. L. O.
.

18th Dec 2015 7:15pm

CharlieBaja

Member Since: 01 Feb 2016
Location: Surrey
Posts: 52

2007 Range Rover Autobiography TDV8 Buckingham Blue

very informative write up, does this apply the same way for the 3.6 TDV8?

3rd May 2016 12:20pm

ajac8

Member Since: 04 Oct 2011
Location: Shakespeares County
Posts: 1672

2013 Range Rover Autobiography SDV8 Baltic Blue

Nice one. How much fuel spillage (if any) should you expect? 405 AB exec seats Baltic and Cirrus
93 RR Classic efi

Remember it's easier to get forgiveness than permission!

Gone in order:
4.4 TDV8 SE - gone to a good home
93 Classic hard dash Plymouth Blue
03 L322 Oslo Blue
2000 Disco TD5 ES Epsom Green
98 P38 Rioja Red
89 Classic Cairngorm Brown

3rd May 2016 4:47pm

EmiratesA380

Member Since: 14 Jan 2015
Location: england
Posts: 361

Hi ajacB

nothing really, may be a teaspoon full - just ensure you wear some plastic gloves ( Diesel smells ) - you might find the collar nut a bit tight - you know what workshops are like ( OTT ) - I nipped mine up and have never had a problem.

having said all this - I ve changed them often and have never found any water in the system - I can only think if you go to a doggie garage that does not turn fuel around fast - then they might have water in their tanks.

For anyone who lives near FLOODED PETROL STATIONS can might get flooded - stay clear as this will cause problems I am sure.

.

4th May 2016 8:15pm

Edfors

Member Since: 26 Oct 2012
Location: Uppsala
Posts: 168

2008 Range Rover Vogue TDV8 Alaska White

CharlieBaja wrote:
very informative write up, does this apply the same way for the 3.6 TDV8?

Yes!

Supporter and maintainer of EDF - Mrs Edfors' shopping cart.

4th May 2016 8:45pm

Mcfly309

Member Since: 24 Mar 2016
Location: North Lincolnshire-ish
Posts: 76

2012 Range Rover Westminster TDV8 Orkney Grey

Just changed mine by following the instructions.
Collar was a bit tight so found that taking the bracket completely off, and disconnecting the lead made undoing it easier (for me anyway) to gain access to the collar.
Another few quid saved thanks to this forum.

27th Sep 2016 4:49pm

Bebert53

Member Since: 26 Nov 2016
Location: mayenne
Posts: 9

2011 Range Rover HSE TDV8 Stornoway Grey

Re: FUEL FILTER ON TDV8 4.4

Unnecessary quote removed

i only want to drain the water

is it any problem?

26th Nov 2016 7:25pm

kbald

Member Since: 17 Aug 2015
Location: Leeds
Posts: 492

2007 Range Rover Vogue TDV8 Buckingham Blue

Sorry to resurrect an old thread but can anyone tell me if this process is the same on the 3.6TDV8 or if not is there a separate write up on how to do this one?

I have had a search but I am not coming up with anything. Its service time again and they have suggested a replacement fuel filter will be needed but at £100 for this bit it seems like a good job to do myself if its as easy as the thread suggests on mine. Thanks Current 2007 TDV8 Vogue Buckingham Blue

1st Jun 2017 6:52pm

GGDR

Member Since: 26 Nov 2016
Location: London
Posts: 3561

2011 Range Rover Vogue SE TDV8 Stornoway Grey

Just done mine, THANK YOU Emirates380 as always for your guide.

I wonder if somebody could tell me if I have the filter up high enough? The gap I'm looking to check is above the plastic collar.
I didn't note the gap taking the old one off.

I also would recommend a rubber strap type oil filter tool to avoid damaging the collar with metal grips like I did.

.. Cheers, Greg
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
2011 Vogue SE 4.4 with lots of toys in Stornaway

22nd Jul 2018 11:04am

stan
Site Moderator

Member Since: 13 Jul 2010
Location: a moderate moderated moderator moderating moderately in moderation
Posts: 35878

mine is screwed right up greg,

... - .- -.

Y. O. L. O.
.

22nd Jul 2018 11:13am

GGDR

Member Since: 26 Nov 2016
Location: London
Posts: 3561

Ah thanks Stan, you're a gent!
It slips up over the pickup tube, no thread.
Then the locking ring turns to secure it.
I'd better try a bit harder!!!! Cheers, Greg
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
2011 Vogue SE 4.4 with lots of toys in Stornaway

Last edited by GGDR on 22nd Jul 2018 12:14pm. Edited 1 time in total

22nd Jul 2018 11:26am

Baltic Blue

Member Since: 13 Aug 2015
Location: North Wales
Posts: 3883

2011 Range Rover Vogue SE TDV8 Baltic Blue

Greg,
Mine doesnâ€™t look quite square.
Itâ€™s up flush at the front but a small gap at the back?

Sorry pictures not brilliant, itâ€™s a bit dark, very cloudy and overcast today.

Mike G reg 2.5VM Vogue Portofino red 1991- 1999
V reg 2.5td P38 Rioja red 1999- 2006
53 reg td6 Vogue Oslo blue 2006- 2015
11 reg 4.4 TdV8 Vogue SE. Baltic blue 2015- date.
https://www.fullfatrr.com/forum/topic56162...tty+affair

22nd Jul 2018 11:47am

Page 1 of 2

All times are GMT

Jump to

< Previous Topic | Next Topic >

Posting Rules

You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot vote in polls in this forum