Hi,

There is a burning smell from the wheels of our S/C after use. On short and long runs but I stress the car is not at all being driven hard (now had car back from a 2 week stay with main dealer for 7 days/300 miles).

Any ideas please?

Thanks

Last edited by pld118 on 10th Aug 2013 1:37pm. Edited 3 times in total

Sounds like another classic SC problem, the brake calipers being stuck. Normally the rear calipers suffer this problem and most of us have had them changed. Sometimes it is accompanied by strange vibrations and "holding back". I initially feared a gearbox issue but then noticed the smell and hot rear disc.

Try to track it down to one of the wheels, go for a little drive and then stop and hold your hand close to the discs to see which one seems hotter than the other. That is the one that needs changing. Best it to change both rear calipers, they relatively cheap to change out (I paid 70 Euro each for exchange of the old ones).

The front calipers (Brembo) usually seem to be fine. MY 2010 5.0 SC Galway green and sand interior!!
Have the Faultmate MSV2 Extreme to be tinkering with the settings etc. !!

Thanks/ v much.. Will let you know later

I've had smoke pouring from my calipers before, plus a very bad shimmy through the steering wheel. At least your mpg will go up a wee bit once fixed

Would you please be able to elaborate as to how the steering shimmy manifested itself (main dealer -1week ago - replaced Servotronic valve and was asked to/ said they did fully inspect/ callipers, discs & pads and only query they found was to clean front brakes. I have queried that steering did still feel something small amiss too)?

Thanks

Violent shaking through the steering wheel, made the car undriveable . Never had a car react like that due to sticky caliper, Although never had such a heavy car either. Just go for a wee run as described above & touch your wheels when you pull over, it will be very obvious if any are stuck, as the wheel will be hot.

Last edited by pld118 on 26th May 2013 6:14am. Edited 1 time in total

There is no smoke nor violent vibration through steering. Took car for a reasonable drive and the smell is coming from front offside wheel. None of wheels were particularly hot. As mentioned, car was only given back by dealer a week ago and they had done some cleaning of front brakes after being asked to specifically check all car's callipers, discs and pads to reassure me they were not in need of near future replacement following other issues I had that called into question the effectiveness of selling main dealer's pre sale multi point inspection.

Will contact local main dealer...

Just a thought, might it be the fuel burning heater kicking in? Can smell a bit when lit, and will still kick in on these cool mornings to help warm the engine. There is nothing that can't be fixed with a hammer😜😜
FFRR 4.4 SDV8 Autobiography Santorini Black.
Fiat 500x 1.4 multiair Lounge 2015
2010 LR D4 Commercial 2.7 TDV6

on a SC ?

Dont sc have a heater? Ah well another reason to buy a tdv8...  There is nothing that can't be fixed with a hammer😜😜
FFRR 4.4 SDV8 Autobiography Santorini Black.
Fiat 500x 1.4 multiair Lounge 2015
2010 LR D4 Commercial 2.7 TDV6

My SC has the heater. Optional extra  Alcohol and eBay is never a good mix

2006 4.2 Supercharged, Java Black

Without knowing options, how can you tell it's fitted please?

you will have the timer option on your screen menu Ryan. ... - .- -.




click link for ,

FORUM WIKI

HOW TO Ǝꓕ∀ꓕOꓤ PICS

workshop manual downloads are in our wiki

.

And a big silver Webastro box with an exhaust on the inner wing...